A PDS or Precision Drive System is a unique drive manufactured by EZGO starting in 2000. This part includes a separate motor that creates the capability of regenerative braking and includes a programmable controller for easier maintenance of your cart's engine. It is not completely programmable, like some carts.
What does PDS mean on EZGO?
EZGO PDS (Precision Drive System) Electronic Speed Controller Performance Plugs.
What does DCS stand for EZGO?
1. For EZ-GO Regen carts, you must determine if it is a DCS (Drive Control System) or PDS (Power Drive System) cart. This can be determined by the type of Forward/Reverse switch and controller.
How do I test my EZGO PDS controller?
PDS TEST AT THE 10 PIN CONNECTOR OF THE CONTROLLER
Place the (+) probe on the black wire terminal of the connector. The reading should be slightly above 14 volts but LESS than 16 volts. If the voltage is below 14 volts, the Throttle Sensor MAY be faulty. Above 16 volts, the controller MAY be faulty.
How do I know if my golf cart controller is bad?
X Common Symptoms of Controller Failure
- Top Speeds Not Appropriate for Your Cart. Golf carts are designed to reach pretty specific speeds and to not go over them or beneath them. ...
- Sudden and Unexpected Slowing. ...
- Shuttering or Shaky Driving. ...
- Stalling Out and Refusing to Start. ...
- Surges in Speed When Driving.
What does a potentiometer do on a golf cart?
It sends an electrical signal to the speed controller from the accelerator pedal, indicating the pedal's position. When it is working properly, the potentiometer allows your golf cart to accelerate smoothly.
How do I speed up my EZGO TXT?
Increasing the speed of your EZ Go golf cart can be done by reprograming your speed control at the dealer, upgrading your batteries, motor, or replacing your speed control. Upgrading these can increase your typical speed from 12 MPH to 19.5 mph or above depending on your modifications.
What is a IQ golf cart?
In 2002 Club Car came out with what they called the IQ system. It consists of a shunt wound motor/controller combination much like the older Regen 1 and Regen 2 (PowerDrive Plus) carts. All DS IQ cars have a serial number prefix of “AQ” All Precedents are equipped with either the IQ or Excel system.
Is My Club Car IQ?
The easiest way to tell is by checking the serial number prefix. If your serial numbers starts with: AQ, CE, FD, HD, PE, or PQ then you have a cart with a IQ system. You can also look at the motor controller part number. If your model number starts with "1510" then you also have an IQ system.
What type of EZGO do I have?
The serial number and manufacturer's number for these EZGO golf cart models can be found on a plate located under the glove box on the passenger's side of the vehicle. The serial number is either six or seven numbers and does not indicate the model year. The manufacturer's number does reflect the model year.
How do I read my EZGO serial number?
E-Z-GO Medalist & TXT Models (1994-Present)
Serial numbers consist of 6 or 7 numbers and do NOT indicate the year the golf cart was manufactured. Manufacturer numbers consist of 1 letter AND between 3 or 4 numbers. The last two numbers indicate the year the cart was manufactured.
How do you check the EZGO inductive throttle sensor?
Identify the six- or 10-pin connector and carefully pull it out so that you can measure the pins. Put the key in the “On” position in your Run/Tow switch on the cart. Switch the F/R switch into a forward position to test your cart. Place your voltimeter testing pins on the throttle pins to see how much voltage you get.
What size battery for EZ GO golf cart?
An EZGo golf cart has either 3, 4, 6, or 8, golf cart batteries. The average golf cart will need 4 to 6 batteries (mostly 6) for optimum performance.
How can I make my 48 volt club car faster?
6 Ways You Can Make a Golf Cart Faster
- Add More Torque to Your Golf Cart.
- Upgrade Your Golf Cart's Motor.
- Improve the High-Speed Controller of the Cart.
- Add Better Golf Cart Tires.
- Use a Higher Powered Golf Cart Battery.
- Watch the Weight in Your Golf Cart.
How do I know what model my club car is?
The serial number on your Club Car can help you determine the model year. The serial number of each vehicle is printed on a bar code decal mounted either below the passenger side cup holder or above the accelerator or brake pedal (Example: PH0901-123456, as shown, or F9901123456).
What motor does my club car have?
What Engines Do Club Car Golf Carts Use? The gas model of the Club Car DS has a single-cylinder 286 CC engine that, combined with an overhead value of 60K, a pressure-lubricated design with air cooling, and a six-speed automatic transmission. Usually, they can make about nine quarts of beer.
Is 30 mph fast for a golf cart?
Depending on how far you want to go on a full charge, you might want a 40mph or a 30mph golf cart. At top speed, most golf carts do around 14mph. However, with the advent of street legal golf carts and modifications, it is possible to go 35mph and above.
How fast can EZ Go TXT go?
Electric Motors
Looking at the specifications for EZ Go electric golf carts, you notice a cart with a 36-volt motor is capable of 12 to 14 mph top speed. In addition, you notice a cart that's powered by a 48-volt motor can reach speeds just below 20 mph.
Can you make a golf cart faster?
Increase Your Golf Cart Speed Today
Depending on your current golf cart's rotations per minute and tire size, it's totally possible to upgrade its speed, torque, and more.
How long do electric golf cart motors last?
How Long Does A Golf Cart Motor Last? A typical gas or electric golf cart motor is designed to last about 20 – 30 years if cared for properly. Despite this, many people do not take care of their golf cart motors.
What can go wrong with an electric golf cart?
5 Common Electric Golf Cart Problems and How to Solve Them
- Troubleshooting Batteries. Like any electric vehicle, the battery is often the root of the problem. ...
- Ignition or Motor Issues. ...
- Solenoid Woes. ...
- Faulty Direction Switch. ...
- No Speed Control.
Why is my electric golf cart sputtering?
The most common reason for your golf cart jerking is often the battery terminal connections are loose and/or corroded. A poor connection prevents the correct amount of current from flowing through the set of batteries to your speed controller (or resistor coil), and ultimately to your electric motor.
What happens when golf cart solenoid goes bad?
If the solenoid is broken and not working correctly, you may notice your golf cart won't start, picking up speed, or even working at all (issues with acceleration could also be caused by a bad speed controller).
How do you test a golf cart speed controller?
Connect the negative probe to the controller's M terminal and positive probe to the B+ terminal. Press the accelerator and watch to see if the voltage increases. It should increase from a reading of 0 to the full voltage of the battery. If the motor is not turning, the problem may be in the directional switch or motor.
