Why is my golf cart slow with new batteries?

Perhaps the most common reason that a golf cart slows down is when it doesn't have enough power output from your battery. Often, this occurs if the battery pack charge is too low and your cart is out of power.

What causes a golf cart to run slow?

Low Battery

Usually, the most common reason golf carts slow down is when they don't get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.

Why does my electric golf cart hesitate when I accelerate?

If your cart does not start smoothly, hesitates before starting, or does not gain speed properly, these are all signs of a bad or damaged accelerator.

How can I make my golf cart battery go faster?

6 Ways You Can Make a Golf Cart Faster

Add More Torque to Your Golf Cart.
Upgrade Your Golf Cart's Motor.
Improve the High-Speed Controller of the Cart.
Add Better Golf Cart Tires.
Use a Higher Powered Golf Cart Battery.
Watch the Weight in Your Golf Cart.

How do you reset golf cart batteries?

Easily Reset the Club Car Golf Cart OBC

Key switch to off.
Set forward/reverse to neutral.
Put tow/run switch to tow.
Disconnect the negative battery terminal from the battery pack.
Put the tow/run switch to run.
Put forward/reverse switch to reverse.
Put key switch to on.

36 related questions found

Where is the reset button on electric golf cart motor?

First, you'll want to reset your motor.

It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!

Where is the reset button on electric golf cart?

Locate the motor

Remove the panel so the electric motor is visible. Electric motors usually include reset buttons that can perform similar to circuit breakers. Look in the area where several electrical wires enter the motor and locate a small red button. This is the reset button.

Where is the speed sensor located on a Club Car golf cart?

Typically, the speed sensor can be found on the backside of the motor. When removing the speed sensor, unplug all the cables that are on the backside of the motor. To do this, use a socket to take off the connector pigtail. Then, remove its plastic housing over the sensor.

How do I increase the speed of my EZ Go golf cart?

One way to increase the speed of EZ Go golf carts is to incorporate an octane booster when you fill the tank. The cart will have more pick-up, and it could gain as much as 5 mph. A different approach is to take out the throttle linkage governor on the carburetor.

How do I know if my electric golf cart motor is bad?

You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.

How do I know if my golf cart controller is bad?

When your golf cart's speed controller isn't operating correctly, your cart will show it by running erratically or failing to drive at one constant speed. If your cart starts showing these symptoms, the first thing you should look at is your speed controller.

How do I know if my golf cart solenoid is bad?

Press on the accelerator while the key is turned on and the cart is in forward.

The solenoid needs to be replaced IF the voltmeter shows a full battery voltage without a click.
If your voltmeter stays at 0, the problem stems from somewhere else in your cart.

Why does my golf cart go slow up hills?

While battery problems tend to be the most common reason for slow speeds uphill. The size of your tires, speed, wire corrosion, and brake solenoid damage are also possible causes for your cart's slow speeds. I recommend checking your batteries before anything else.

Why is my golf cart losing power up hills?

When your electric golf cart struggles on inclines, it means that you have to work harder to lift the front wheels. The cart's batteries interfere with its acceleration, and your speed decreases.

What controls the speed of a golf cart?

Essentially, your golf cart's speed controller sends its current and battery voltage to its motor. This process depends on your golf cart's input device, which includes its throttle. That's how your golf cart's speed controller lets you operate its acceleration rate, as well as its deceleration rate.

How do I test my golf cart speed controller?

Connect the negative probe to the controller's M terminal and positive probe to the B+ terminal. Press the accelerator and watch to see if the voltage increases. It should increase from a reading of 0 to the full voltage of the battery. If the motor is not turning, the problem may be in the directional switch or motor.

What does a golf cart speed sensor do?

No matter what the type of engine you use – such as AC or DC motors – a speed sensor is critical. They help to detect the motor's RPM to the controller of the cart and helps to make regenerative braking more useful.

How does a golf cart speed sensor work?

Magnetic Style

Many golf cart motor speed sensors employ an electromagnetic power to “read” the motor rpm. Generally, there is a magnet present in the closed end of the motor as well as the sensor itself which reads how the magnet is reacting with the magnetic field inside the motor.

How do you adjust the governor on a golf cart?

If you find this rod, then your governor can be easily adjusted by accessing the cart's inner workings. Simply adjust the cable coming from this metal protrusion, turning the nut counterclockwise to make the cable longer, effectively adjusting the cart's governance to increase the overall speed.

How do you take a limiter off a golf cart?

General Instructions

Detach the cable from the carburetor. The cable is about the width of a straw. ...
Follow the disconnected cable up to the governor. ...
Disconnect the gas pedal cable from the governor and reroute it to the carburetor. ...
Using your wrench, remove the bolt on the gas pedal shaft.

How do you make a club car go faster?

Increase Speed On A Golf Cart

There are simple ways to increase the speed of your Club Car golf cart. ...
For example, you could start by upgrading the controller, adding a heavy-duty forward reverse switch, then upgrade the existing motor, install a solenoid, battery, cables and—well, you get the idea.